And as to the Kilns, in which the firing takes place, and in which some of the more precious articles are burnt repeatedly, in various stages of their process towards completion, - as to the Kilns (says the plate, warming with the recollection), if you don't remember THEM with a horrible interest, what did you ever go to Copeland's for? When you stood inside of one of those inverted bowls of a Pre-Adamite tobacco-pipe, looking up at the blue sky through the open top far off, as you might have looked up from a well, sunk under the centre of the pavement of the Pantheon at Rome, had you the least idea where you were? And when you found yourself surrounded, in that dome-shaped cavern, by innumerable columns of an unearthly order of architecture, supporting nothing, and squeezed close together as if a Pre-Adamite Samson had taken a vast Hall in his arms and crushed it into the smallest possible space, had you the least idea what they were? No (says the plate), of course not! And when you found that each of those pillars was a pile of ingeniously made vessels of coarse clay - called Saggers - looking, when separate, like raised-pies for the table of the mighty Giant Blunderbore, and now all full of various articles of pottery ranged in them in baking order, the bottom of each vessel serving for the cover of the one below, and the whole Kiln rapidly filling with these, tier upon tier, until the last workman should have barely room to crawl out, before the closing of the jagged aperture in the wall and the kindling of the gradual fire; did you not stand amazed to think that all the year round these dread chambers are heating, white hot - and cooling - and filling - and emptying - and being bricked up - and broken open - humanly speaking, for ever and ever? To be sure you did! And standing in one of those Kilns nearly full, and seeing a free crow shoot across the aperture a-top, and learning how the fire would wax hotter and hotter by slow degrees, and would cool similarly through a space of from forty to sixty hours, did no remembrance of the days when human clay was burnt oppress you? Yes. I think so! I suspect that some fancy of a fiery haze and a shortening breath, and a growing heat, and a gasping prayer; and a figure in black interposing between you and the sky (as figures in black are very apt to do), and looking down, before it grew too hot to look and live, upon the Heretic in his edifying agony - I say I suspect (says the plate) that some such fancy was pretty strong upon you when you went out into the air, and blessed God for the bright spring day and the degenerate times!
After that, I needn't remind you what a relief it was to see the ******st process of ornamenting this 'biscuit' (as it is called when baked) with brown circles and blue trees - converting it into the common crockery-ware that is exported to Africa, and used in cottages at home. For (says the plate) I am well persuaded that you bear in mind how those particular jugs and mugs were once more set upon a lathe and put in motion; and how a man blew the brown colour (having a strong natural affinity with the material in that condition) on them from a blowpipe as they twirled; and how his daughter, with a common brush, dropped blotches of blue upon them in the right places; and how, tilting the blotches upside down, she made them run into rude images of trees, and there an end.
And didn't you see (says the plate) planted upon my own brother that astounding blue willow, with knobbed and gnarled trunk, and foliage of blue ostrich feathers, which gives our family the title of 'willow pattern'? And didn't you observe, transferred upon him at the same time, that blue bridge which spans nothing, growing out from the roots of the willow; and the three blue Chinese going over it into a blue temple, which has a fine crop of blue bushes sprouting out of the roof; and a blue boat sailing above them, the mast of which is burglariously sticking itself into the foundations of a blue villa, suspended sky-high, surmounted by a lump of blue rock, sky-higher, and a couple of billing blue birds, sky-highest - together with the rest of that amusing blue landscape, which has, in deference to our revered ancestors of the Cerulean Empire, and in defiance of every known law of perspective, adorned millions of our family ever since the days of platters? Didn't you inspect the copper-plate on which my pattern was deeply engraved? Didn't you perceive an impression of it taken in cobalt colour at a cylindrical press, upon a leaf of thin paper, streaming from a plunge-bath of soap and water? Wasn't the paper impression daintily spread, by a light-fingered damsel (you KNOW you admired her!), over the surface of the plate, and the back of the paper rubbed prodigiously hard - with a long tight roll of flannel, tied up like a round of hung beef - without so much as ruffling the paper, wet as it was? Then (says the plate), was not the paper washed away with a sponge, and didn't there appear, set off upon the plate, THIS identical piece of Pre-Raphaelite blue distemper which you now behold? Not to be denied! I had seen all this - and more. I had been shown, at Copeland's, patterns of beautiful design, in faultless perspective, which are causing the ugly old willow to wither out of public favour; and which, being quite as cheap, insinuate good wholesome natural art into the humblest households. When Mr. and Mrs. Sprat have satisfied their material tastes by that equal division of fat and lean which has made their MENAGE immortal; and have, after the elegant tradition, 'licked the platter clean,' they can - thanks to modern artists in clay - feast their intellectual tastes upon excellent delineations of natural objects.
This reflection prompts me to transfer my attention from the blue plate to the forlorn but cheerfully painted vase on the sideboard.
And surely (says the plate) you have not forgotten how the outlines of such groups of flowers as you see there, are printed, just as I was printed, and are afterwards shaded and filled in with metallic colours by women and girls? As to the aristocracy of our order, made of the finer clay-porcelain peers and peeresses; - the slabs, and panels, and table-tops, and tazze; the endless nobility and gentry of dessert, breakfast, and tea services; the gemmed perfume bottles, and scarlet and gold salvers; you saw that they were painted by artists, with metallic colours laid on with camel-hair pencils, and afterwards burnt in.
And talking of burning in (says the plate), didn't you find that every subject, from the willow pattern to the landscape after Turner - having been framed upon clay or porcelain biscuit - has to be glazed? Of course, you saw the glaze - composed of various vitreous materials - laid over every article; and of course you witnessed the close imprisonment of each piece in saggers upon the separate system rigidly enforced by means of fine-pointed earthenware stilts placed between the articles to prevent the slightest communication or contact. We had in my time - and I suppose it is the same now - fourteen hours' firing to fix the glaze and to make it 'run' all over us equally, so as to put a good shiny and unscratchable surface upon us. Doubtless, you observed that one sort of glaze - called printing-body - is burnt into the better sort of ware BEFORE it is printed. Upon this you saw some of the finest steel engravings transferred, to be fixed by an after glazing - didn't you? Why, of course you did!
Of course I did. I had seen and enjoyed everything that the plate recalled to me, and had beheld with admiration how the rotatory motion which keeps this ball of ours in its place in the great scheme, with all its busy mites upon it, was necessary throughout the process, and could only be dispensed with in the fire. So, listening to the plate's reminders, and musing upon them, I got through the evening after all, and went to bed. I made but one sleep of it - for which I have no doubt I am also indebted to the plate - and left the lonely Dodo in the morning, quite at peace with it, before the bandy-legged baby was up.